Hyundai Sonata: Engine Mechanical System / Cylinder Block
- Components and Components Location
- External Damper Flywheel Components and Components Location
- External Damper Flywheel Repair procedures
- Water Jacket Seperator Components and Components Location
- Water Jacket Seperator Repair procedures
- Rear Oil Seal Components and Components Location
- Rear Oil Seal Repair procedures
- Cylinder Block Components and Components Location
- Cylinder Block Repair procedures
Cylinder Head Repair procedures
Removal
Engine removal is not required for this procedure.
•
Use fender covers to avoid damaging painted surfaces.
•
To avoid damaging the cylinder head, wait u ...
Components and Components Location
Components
1. Cylinder block2. Ladder frame3. Crankshaft4. Crankshaft upper bearing5. Crankshaft lower bearing6. Thrust bearing7. Main bearing cap8. External damper flywheel9. Crankshaft sproket1 ...
Other information:
Hyundai Sonata LF 2014-2019 Service Manual: Heater & A/C Control Unit (DATC) Components and Components Location
Components
Connector [A]
Pin NOFunctionPin NOFunction1ILL+ (TAIL)21Detent OUT (+)2Sensor REF (+5V)22HTD (Rear defog indicator)3Mode control actuator (Vent)23Rear defog switch4Mode control actuator (Defrost)24C_CAN High5Mode control actuator (Feedback)25C_CAN Low6Intake actuator (Fresh)26ECV+7Int ...
Hyundai Sonata LF 2014-2019 Service Manual: Receiver-Drier Repair procedures
Replacement
1.
Remove the condenser.
2.
Remove the cap (B) on the bottom of the condenser with a L wrench [Hex 14] (A).
Tightening torque :
4.0 ± 1.0 N.m (0.41 ± 0.1 kgf.m, 2.95 ± 0.72 lbf-ft)
3.
Remove the receiver-drier (A) from condenser using a long
nose plier. Check fo ...