Hyundai Sonata LF: Driveshaft and axle / General Information

Hyundai Sonata LF 2014-2019 Service Manual / Driveshaft and axle / General Information

Specifications

Specifications
Joint type
Max. permissible angle
Outer
Inner
Outer
Inner
BJ#95
LSJ#95
45°
21°
BJ#104
LSJ#100
45°
21°

Tightening Torques
Item
N.m
kgf.m
Ib.ft
Front
Wheel nut
88.3 ~ 107.9
9.0 ~ 11.0
65.1 ~ 79.6
Drive shaft castle nut
274.6 ~ 294.2
28.0 ~ 30.0
202.5 ~ 217.1
Strut assembly lower mounting bolt
196.1 ~ 215.7
20.0 ~ 22.0
144.7 ~ 159.1 
Hub assembly mounting bolts
78.5 ~ 98.1
8.0 ~ 10.0
57.9 ~ 72.3
Brake caliper mounting bolt
78.5 ~ 98.1
8.0 ~ 10.0
57.9 ~ 72.3
Wheel speed sensor mounting bolt
8.8 ~ 13.7
0.9 ~ 1.4
6.5 ~ 10.1
Brake disc mounting bolt
4.9 ~ 5.8
0.5 ~ 0.6
3.6 ~ 4.3
Lower ball joint mounting bolt
98.1 ~ 117.7
10.0 ~ 12.0
72.3 ~ 86.8
Tie rod end ball joint nut
34.3 ~ 44.1
3.5 ~ 4.5
25.3 ~ 32.5
Rear
Wheel nut
88.3 ~ 107.9
9.0 ~ 11.0
65.1 ~ 79.6
Shock absorber upper mounting bolt
49.0 ~ 63.7
5.0 ~ 6.5
36.2 ~ 47.0
Shock absorber lower mounting nut
137.3 ~ 156.9
14.0 ~ 16.0
101.3 ~ 115.7
Brake caliper mounting bolt
78.4 ~ 98.0
8.0 ~ 10.0
57.8 ~ 72.3
Wheel speed sensor mounting bolt
8.8 ~ 13.7
0.9 ~ 1.4
6.5 ~ 10.1
Brake disc mounting bolt
4.9 ~ 5.8
0.5 ~ 0.6
3.6 ~ 4.3
Hub assembly mounting bolt
58.8 ~ 68.6
6.0 ~ 7.0
43.4 ~ 50.6
Upper arm mounting bolt & nut
137.3 ~ 156.9
14.0 ~ 16.0
101.3 ~ 115.7
Lower arm mounting bolt & nut
137.3 ~ 156.9
14.0 ~ 16.0
101.3 ~ 115.7
Assist armt mounting bolt & nut
137.3 ~ 156.9
14.0 ~ 16.0
101.3 ~ 115.7
Trailing arm mounting bolt
98.1 ~ 117.7
10.0 ~ 12.0
72.3 ~ 86.7

Lubricants
Engine
Lubricants
Quantity (g)
THETA2.4 GDI
A/T RH
BJ
GRB006N(CVBJ-2)
105 + 10
A/T LH
100 + 10
A/T RH
LSJ(TJ)
VX712(CVTJ-2)
170 + 15
A/T LH
THETA2.0 T-GDI
A/T RH
BJ
GRB006N(CVBJ-2)
135 + 10
A/T LH
A/T RH
LSJ(TJ)
VX712(CVTJ-2)
215 + 15
A/T LH
GAMMA1.6 T-GDI
7DCT
BJ
GRB006N(CVBJ-2)
150 + 10
LSJ(TJ)
VX712(CVTJ-2)
215 + 15

Special Service Tools

Special Service Tools
Tool(Number and Name)
Illustration
Use
09495-3K000
Band installer

Installation of ear type boot band
09495-33000
Puller

Removal of spider assembly from a drive shaft.
09495-39100
Band installer

Installation of hook type boot band

Troubleshooting

Troubleshooting
Trouble Symptom
Probable cause
Remedy
Vehicle pulls to one side
Scoring of driveshaft ball joint
Replace
Wear, rattle or scoring of wheel bearing
Replace
Defective front suspension and steering
Adjustment or Replace
Vibration
Wear, damage or bending of driveshaft
Replace
Driveshaft rattle and hub serration
Replace
Wear, rattle or scratching of wheel bearing
Replace
Shimmy
Defective wheel balance
Adjustment or Replace
Defective front suspension and steering
Adjustment or Replace
Excessive noise
Wear, damage or bending of driveshaft
Replace
Rattle of driveshaft and worn hub splines
Replace
Wear, rattle or scoring of wheel bearing
Replace
Loose hub nut
Adjustment or Replace
Defective front suspension and steering
Adjustment or Replace

    Driveshaft and axle

    ..

    Front Axle Assembly

    Front Hub - Axle Components and Components Location Components 1. Brake disc2. Hub bearing3. Dust cover4. Knuckle Front Hub - Axle Repair procedures Replacement Front hub assembly 1...

    Other information:

    Hyundai Sonata LF 2014-2019 Service Manual: Repair procedures


    On-vehicle Inpection     • First of all, check for DTCs. If a DTC is present, perform troubleshooting in accordance with the procedure for that DTC. (Refer to DTC guide)     • Check that the battery cables are connected to the correct terminals...

    Hyundai Sonata LF 2014-2019 Service Manual: Accelerator Pedal Repair procedures


    Removal 1. Turn the ignition switch OFF and disconnect the negative (-) battery cable. 2. Disconnect the accelerator position sensor connector (A). 3. Remove the mounting cap (A). 4. Remove the installation bolt (A), and then remove the accelerator pedal module...

    Categories

    read more

     
    Copyright © 2025 www.hsonatalf.org