Hyundai Sonata: General Information / Specifications
| Specifications |
| Joint type | Max. permissible angle | ||
| Outer | Inner | Outer | Inner |
| BJ#95 | LSJ#95 | 45° | 21° |
| BJ#104 | LSJ#100 | 45° | 21° |
| Tightening Torques |
| Item | N.m | kgf.m | Ib.ft | |
| Front | Wheel nut | 88.3 ~ 107.9 | 9.0 ~ 11.0 | 65.1 ~ 79.6 |
| Drive shaft castle nut | 274.6 ~ 294.2 | 28.0 ~ 30.0 | 202.5 ~ 217.1 | |
| Strut assembly lower mounting bolt | 196.1 ~ 215.7 | 20.0 ~ 22.0 | 144.7 ~ 159.1 | |
| Hub assembly mounting bolts | 78.5 ~ 98.1 | 8.0 ~ 10.0 | 57.9 ~ 72.3 | |
| Brake caliper mounting bolt | 78.5 ~ 98.1 | 8.0 ~ 10.0 | 57.9 ~ 72.3 | |
| Wheel speed sensor mounting bolt | 8.8 ~ 13.7 | 0.9 ~ 1.4 | 6.5 ~ 10.1 | |
| Brake disc mounting bolt | 4.9 ~ 5.8 | 0.5 ~ 0.6 | 3.6 ~ 4.3 | |
| Lower ball joint mounting bolt | 98.1 ~ 117.7 | 10.0 ~ 12.0 | 72.3 ~ 86.8 | |
| Tie rod end ball joint nut | 34.3 ~ 44.1 | 3.5 ~ 4.5 | 25.3 ~ 32.5 | |
| Rear | Wheel nut | 88.3 ~ 107.9 | 9.0 ~ 11.0 | 65.1 ~ 79.6 |
| Shock absorber upper mounting bolt | 49.0 ~ 63.7 | 5.0 ~ 6.5 | 36.2 ~ 47.0 | |
| Shock absorber lower mounting nut | 137.3 ~ 156.9 | 14.0 ~ 16.0 | 101.3 ~ 115.7 | |
| Brake caliper mounting bolt | 78.4 ~ 98.0 | 8.0 ~ 10.0 | 57.8 ~ 72.3 | |
| Wheel speed sensor mounting bolt | 8.8 ~ 13.7 | 0.9 ~ 1.4 | 6.5 ~ 10.1 | |
| Brake disc mounting bolt | 4.9 ~ 5.8 | 0.5 ~ 0.6 | 3.6 ~ 4.3 | |
| Hub assembly mounting bolt | 58.8 ~ 68.6 | 6.0 ~ 7.0 | 43.4 ~ 50.6 | |
| Upper arm mounting bolt & nut | 137.3 ~ 156.9 | 14.0 ~ 16.0 | 101.3 ~ 115.7 | |
| Lower arm mounting bolt & nut | 137.3 ~ 156.9 | 14.0 ~ 16.0 | 101.3 ~ 115.7 | |
| Assist armt mounting bolt & nut | 137.3 ~ 156.9 | 14.0 ~ 16.0 | 101.3 ~ 115.7 | |
| Trailing arm mounting bolt | 98.1 ~ 117.7 | 10.0 ~ 12.0 | 72.3 ~ 86.7 | |
| Lubricants |
| Engine | Lubricants | Quantity (g) | ||
| THETA2.4 GDI | A/T RH | BJ | GRB006N(CVBJ-2) | 105 + 10 |
| A/T LH | 100 + 10 | |||
| A/T RH | LSJ(TJ) | VX712(CVTJ-2) | 170 + 15 | |
| A/T LH | ||||
| THETA2.0 T-GDI | A/T RH | BJ | GRB006N(CVBJ-2) | 135 + 10 |
| A/T LH | ||||
| A/T RH | LSJ(TJ) | VX712(CVTJ-2) | 215 + 15 | |
| A/T LH | ||||
| GAMMA1.6 T-GDI | 7DCT | BJ | GRB006N(CVBJ-2) | 150 + 10 |
| LSJ(TJ) | VX712(CVTJ-2) | 215 + 15 | ||
Special Service Tools
Special Service Tools
Tool(Number and Name)IllustrationUse09495-3K000Band installerInstallation of ear type boot band09495-33000PullerRemoval of spider assembly from a drive shaft.09495-39100Band ...
Other information:
Hyundai Sonata LF 2014-2019 Service Manual: SRS Control Module (SRSCM) Repair procedures
Removal
1.
Remove the ignition key from the vehicle.
2.
Disconnect the battery negative cable and wait for at least three minutes before beginning work.
3.
Remove the floor console.
(Refer to Body - "Floor Console Assembly")
4.
Pull up the lock (C), of the SRSCM connector, then disc ...
Hyundai Sonata LF 2014-2019 Service Manual: Auto Head Lamp Leveling Unit Troubleshooting
Inspection with GDS
Initialization and diagnosis sequence by using GDS equipment.
Below content summarize the procedure for A/S using GDS.
NoProcedure1Locate vehicle to flat plane2Tire check3IGN1 ON4Head lamp Low Beam ON5Connection with diagnostic tool6Initial command by diagnostic tool7Clear ...
