Hyundai Sonata LF: Driveshaft and axle / General Information

Hyundai Sonata LF 2014-2019 Service Manual / Driveshaft and axle / General Information

Specifications

Specifications
Joint type
Max. permissible angle
Outer
Inner
Outer
Inner
BJ#95
LSJ#95
45°
21°
BJ#104
LSJ#100
45°
21°

Tightening Torques
Item
N.m
kgf.m
Ib.ft
Front
Wheel nut
88.3 ~ 107.9
9.0 ~ 11.0
65.1 ~ 79.6
Drive shaft castle nut
274.6 ~ 294.2
28.0 ~ 30.0
202.5 ~ 217.1
Strut assembly lower mounting bolt
196.1 ~ 215.7
20.0 ~ 22.0
144.7 ~ 159.1 
Hub assembly mounting bolts
78.5 ~ 98.1
8.0 ~ 10.0
57.9 ~ 72.3
Brake caliper mounting bolt
78.5 ~ 98.1
8.0 ~ 10.0
57.9 ~ 72.3
Wheel speed sensor mounting bolt
8.8 ~ 13.7
0.9 ~ 1.4
6.5 ~ 10.1
Brake disc mounting bolt
4.9 ~ 5.8
0.5 ~ 0.6
3.6 ~ 4.3
Lower ball joint mounting bolt
98.1 ~ 117.7
10.0 ~ 12.0
72.3 ~ 86.8
Tie rod end ball joint nut
34.3 ~ 44.1
3.5 ~ 4.5
25.3 ~ 32.5
Rear
Wheel nut
88.3 ~ 107.9
9.0 ~ 11.0
65.1 ~ 79.6
Shock absorber upper mounting bolt
49.0 ~ 63.7
5.0 ~ 6.5
36.2 ~ 47.0
Shock absorber lower mounting nut
137.3 ~ 156.9
14.0 ~ 16.0
101.3 ~ 115.7
Brake caliper mounting bolt
78.4 ~ 98.0
8.0 ~ 10.0
57.8 ~ 72.3
Wheel speed sensor mounting bolt
8.8 ~ 13.7
0.9 ~ 1.4
6.5 ~ 10.1
Brake disc mounting bolt
4.9 ~ 5.8
0.5 ~ 0.6
3.6 ~ 4.3
Hub assembly mounting bolt
58.8 ~ 68.6
6.0 ~ 7.0
43.4 ~ 50.6
Upper arm mounting bolt & nut
137.3 ~ 156.9
14.0 ~ 16.0
101.3 ~ 115.7
Lower arm mounting bolt & nut
137.3 ~ 156.9
14.0 ~ 16.0
101.3 ~ 115.7
Assist armt mounting bolt & nut
137.3 ~ 156.9
14.0 ~ 16.0
101.3 ~ 115.7
Trailing arm mounting bolt
98.1 ~ 117.7
10.0 ~ 12.0
72.3 ~ 86.7

Lubricants
Engine
Lubricants
Quantity (g)
THETA2.4 GDI
A/T RH
BJ
GRB006N(CVBJ-2)
105 + 10
A/T LH
100 + 10
A/T RH
LSJ(TJ)
VX712(CVTJ-2)
170 + 15
A/T LH
THETA2.0 T-GDI
A/T RH
BJ
GRB006N(CVBJ-2)
135 + 10
A/T LH
A/T RH
LSJ(TJ)
VX712(CVTJ-2)
215 + 15
A/T LH
GAMMA1.6 T-GDI
7DCT
BJ
GRB006N(CVBJ-2)
150 + 10
LSJ(TJ)
VX712(CVTJ-2)
215 + 15

Special Service Tools

Special Service Tools
Tool(Number and Name)
Illustration
Use
09495-3K000
Band installer

Installation of ear type boot band
09495-33000
Puller

Removal of spider assembly from a drive shaft.
09495-39100
Band installer

Installation of hook type boot band

Troubleshooting

Troubleshooting
Trouble Symptom
Probable cause
Remedy
Vehicle pulls to one side
Scoring of driveshaft ball joint
Replace
Wear, rattle or scoring of wheel bearing
Replace
Defective front suspension and steering
Adjustment or Replace
Vibration
Wear, damage or bending of driveshaft
Replace
Driveshaft rattle and hub serration
Replace
Wear, rattle or scratching of wheel bearing
Replace
Shimmy
Defective wheel balance
Adjustment or Replace
Defective front suspension and steering
Adjustment or Replace
Excessive noise
Wear, damage or bending of driveshaft
Replace
Rattle of driveshaft and worn hub splines
Replace
Wear, rattle or scoring of wheel bearing
Replace
Loose hub nut
Adjustment or Replace
Defective front suspension and steering
Adjustment or Replace

    Driveshaft and axle

    ..

    Front Axle Assembly

    Front Hub - Axle Components and Components Location Components 1. Brake disc2. Hub bearing3. Dust cover4. Knuckle Front Hub - Axle Repair procedures Replacement Front hub assembly 1...

    Other information:

    Hyundai Sonata LF 2014-2019 Service Manual: Fuel Pump Control Module (FPCM) Description and Operation


    Description The fuel pump control module (FPCM) is installed on the right side of the fuel tank on the fuel pump top plate and controls the DC motor mounted inside the low pressure fuel pump. The module compares instantaneous fuel pressure information measured by the fuel pressure sensor (FPS) with target fuel pressure information provided by the ECM and generates the desired target fuel pressure by controlling the fuel pump motor and regulating fuel flow rate in the low pressure fuel line between the low and high pressure fuel pumps...

    Hyundai Sonata LF 2014-2019 Service Manual: Transmission Gear Oil General Information


    General Information 1. Check & Change intervals Check & ReplenishmentChangeCapacityOil specificationNormal UseSevere Use60000 km / 4 years(40000 miles / 4 years) No service required120000 km(80000 miles)1.9 L (0.50 U.S gal., 2.00 U.S qt...

    Categories

    read more

     
    Copyright © 2026 www.hsonatalf.org