Hyundai Sonata: General Information / Troubleshooting

Troubleshooting
Trouble Symptom
Probable Cause
Remedy
Excessive play in steering
Loose U-joint bolt
Retighten or replace as necessary
Loose yoke plug
Retighten
Loose steering gear mounting bolts
Retighten
Loose or worn tie rod end
Retighten or replace as necessary
Steering wheel does not return properly
Excessive turning resistance of tie rod end
Replace
Yoke plug excessively tight
Adjust
Tie rod and/or ball joint cannot turn smoothly
Replace
Loose mounting of gear box mounting bracket at the subframe
Retighten
Worn steering shaft joint and/or body grommet
Correct or replace
Distorted rack
Replace
Rattling or chucking noise in the rack and pinion
Loose steering gear box mounting
Reposition
Loose tie rod end and/or ball joint
Retighten
Worn tie rod and/or ball joint
Retighten
Loose yoke plug
Replace

Special Service Tools
Special Service Tools Tool Name / NumberIllustrationDescription90561-11001Steering wheel pullerRemoval of steering wheel ...

Steering wheel
...

Other information:

Hyundai Sonata LF 2014-2019 Service Manual: Repair procedures
On-vehicle Inpection     • First of all, check for DTCs. If a DTC is present, perform troubleshooting in accordance with the procedure for that DTC. (Refer to DTC guide)     • Check that the battery cables are connected to the correct termina ...

Hyundai Sonata LF 2014-2019 Service Manual: Antenna Coil Repair procedures
Removal 1. Disconnect the negative (-) battery terminal. 2. Remove the crash pad lower panel. (Refer to Body - "Crash Pad Lower Panel") 3. Disconnect the 6P connector (B) of the coil antenna and then remove the coil antenna (A) after loosening the screw. Installation 1. Install the ...

© 2018-2021 www.hsonatalf.org