Hyundai Sonata: General Information / Specifications

Specification
Air Conditioner
ltem
Specification
Theta 2.4 GDI
Theta 2.0 T-GDI / Gamma 1.6 T-GDI
Compressor
Type
6SES14
Oil type & Capacity
ND8 (PAG) OIL 80 ± 10 cc (2.82 ± 0.35 oz.)
Pulley type
DL pulley type (A1 - PD)
Displacement
140 cc
Air pressure transducer
Pressure values
Vdd * (0.001758 * Pressure(Psia) + 0.074126
Expansion valve
Type
Block type
Refrigerant
Type
R-134a
Capacity
575 ± 20 g (20.2 ± 0.70 oz.)
525 ± 20 g (18.5 ± 0.70 oz.)

Blower Unit
Item
Specification
Fresh and recirculation
Operating method
Actuator
Blower
Type
Sirocco pan
Speed step
Auto + 8 speed, 1 ~ 4speed (Manual)
Speed control
Power mosfet (Automatic), Resistor (Manual)
Air filter
Type
Particle filter

Heater and Evaporator Unit
Item
Specification
Heater
Type
Fin & Tube type
Heating capacity
4800-5% kcal/hr
Mode operating method
Actuator
Temperature operating method
Actuator
Evaporator
Temperature control type
Evaporator temperature sensor
A/C ON/OFF [°C (°F)]
Max cooling condition
On : -6°C (21.2), Off : -8°C (17.6)
Except above condition
On : -1.5°C (29.3), Off : -0.5°C (31.1)

Tightening Torques
Items
N.m
kgf.m
lb-ft
Compressor
20.0 ~ 32.95
2.04 ~ 3.36
14.75 ~ 24.30
Condenser - Discharge hose
3.9 ~ 5.9
0.4 ~ 0.6
2.9 ~ 4.3
Condenser - Liquid tube
Compressor - Discharge hose
8.8 ~ 13.7
0.9 ~ 1.4
6.5 ~ 10.1
Compressor - Suction hose
Expansion valve - Evaporator
8.8 ~ 13.7
0.9 ~ 1.4
6.5 ~ 10.1

General Information
...

Troubleshooting
Troubleshooting Problem Symptoms Table Before replacing or repairing air conditioning components, first determine if the malfunction is due to the refrigerant charge, air flow or compressor. ...

Other information:

Hyundai Sonata LF 2014-2019 Service Manual: DCT Control Module (TCM) Repair procedures
Inspection Transmission Control Module (TCM) Inspection Procedure 1. Inspecting TCM ground circuit: Measure the resistance between the TCM and chassis ground. (Check the terminal connected to the chassis ground while using the back of the harness connector as the base point for TCM.) ...

Hyundai Sonata LF 2014-2019 Service Manual: Electric Parking Brake (EPB) Repair procedures
EPB Release 1. Turn ignition switch OFF and disconnect the negative (-) battery cable. 2. Connect the GDS to the data link connector located underneath the dash panel. 3. Select and operate according to the instructions on the GDS screen. (1) Select vehicle name. (2) Select EPB. ...

© 2018-2025 www.hsonatalf.org